120 Braley Rd. P.O. Box 429 East Freetown, MA 02717-0429 www.htproducts
10 LP-171 Rev. 4.10.14 C. OPTIONAL EQUIPMENT Below is a li
11 LP-171 Rev. 4.10.14 Failure to keep heater area clear
12 LP-171 Rev. 4.10.14 C. CLEARANCES FOR SERVICE ACCESS Se
13 LP-171 Rev. 4.10.14 E. EXHAUST VENT AND INTAKE PIPE Ve
14 LP-171 Rev. 4.10.14 2. Visually inspect the venting sys
15 LP-171 Rev. 4.10.14 The building frame (studs) must be
16 LP-171 Rev. 4.10.14 5. New plumbing typically has cont
17 LP-171 Rev. 4.10.14 C. SEPARATE LOW WATER CUTOFF A low
18 LP-171 Rev. 4.10.14 SIZING SPACE HEAT SYSTEM PIPING 1.
19 LP-171 Rev. 4.10.14 The chart below represents various
2 LP-171 Rev. 4.10.14 IF THE INFORMATION IN THIS MANUAL
20 LP-171 Rev. 4.10.14 L. FILL AND PURGE HEATING SYSTEM
21 LP-171 Rev. 4.10.14 M. PIPING DETAILS Figure 5
22 LP-171 Rev. 4.10.14 Figure 6 NOTES: 1. This drawing is
23 LP-171 Rev. 4.10.14 Figure 7 NOTES: 1. This drawing is
24 LP-171 Rev. 4.10.14 Figure 8 NOTES: 1. This drawing is
25 LP-171 Rev. 4.10.14 Figure 9 NOTES: 1. This drawing is
26 LP-171 Rev. 4.10.14 Figure 10 NOTES: 1. This drawing i
27 LP-171 Rev. 4.10.14 Figure 11 NOTES: 1. This drawing i
28 LP-171 Rev. 4.10.14 PART 6 – PIPING WITH OPTIONAL VISIO
29 LP-171 Rev. 4.10.14 D. PIPING DETAILS WITH THE VISION 1
3 LP-171 Rev. 4.10.14 The following defined terms are us
30 LP-171 Rev. 4.10.14 Figure 13 NOTES: 1. This drawing i
31 LP-171 Rev. 4.10.14 Figure 14 NOTES: 1. This drawing i
32 LP-171 Rev. 4.10.14 Figure 15 NOTES: 1. This drawing i
33 LP-171 Rev. 4.10.14 Figure 16 NOTES: 1. This drawing i
34 LP-171 Rev. 4.10.14 Figure 17 NOTES: 1. This drawing i
35 LP-171 Rev. 4.10.14 Figure 18 NOTES: 1. This drawing i
36 LP-171 Rev. 4.10.14 Figure 19 – NOTES: 1. This drawing
37 LP-171 Rev. 4.10.14 Figure 20 NOTES: 1. This drawing i
38 LP-171 Rev. 4.10.14 Figure 21 NOTES: 1. This drawing i
39 LP-171 Rev. 4.10.14 PART 7 – VENTING, COMBUSTION AIR, A
4 LP-171 Rev. 4.10.14 The latest version of the National
40 LP-171 Rev. 4.10.14 The exhaust and intake compone
41 LP-171 Rev. 4.10.14 D. EXHAUST VENT AND INTAKE PIPE LOC
42 LP-171 Rev. 4.10.14 The building owner is responsible
43 LP-171 Rev. 4.10.14 Figure 23 – LP-171-R NOTES: 1. Con
44 LP-171 Rev. 4.10.14 Figure 24 – Piping Exhaust around
45 LP-171 Rev. 4.10.14 2. Inspect the area where the whit
46 LP-171 Rev. 4.10.14 H. EXHAUST VENT AND INTAKE PIPE INS
47 LP-171 Rev. 4.10.14 I. DIAGRAMS FOR SIDEWALL VENTING F
48 LP-171 Rev. 4.10.14 J. DIAGRAMS FOR VERTICAL VENTING F
49 LP-171 Rev. 4.10.14 *NOTE: Installer must supply trap
5 LP-171 Rev. 4.10.14 F. CIRCULATORS...
50 LP-171 Rev. 4.10.14 connection to the swirl plate and b
51 LP-171 Rev. 4.10.14 The gas piping must be sized for th
52 LP-171 Rev. 4.10.14 Strain on the gas valve and fittin
53 LP-171 Rev. 4.10.14 Figure 29
54 LP-171 Rev. 4.10.14 Figure 30 – NOTE: A resistor is p
55 LP-171 Rev. 4.10.14 Figure 31 – MC Series Internal Con
56 LP-171 Rev. 4.10.14 Connected in the heater junction b
57 LP-171 Rev. 4.10.14 Connection Specification – Wire 18
58 LP-171 Rev. 4.10.14 B. FREEZE PROTECTION (WHEN USED) N
59 LP-171 Rev. 4.10.14 1. Take the 5/16" flexible cle
6 LP-171 Rev. 4.10.14 F. CHECK FOR GAS LEAKS ...
60 LP-171 Rev. 4.10.14 Never open the manual air vent whi
61 LP-171 Rev. 4.10.14 3. Fill condensate trap with water
62 LP-171 Rev. 4.10.14 To adjust, press either {S1} (Decr
63 LP-171 Rev. 4.10.14 water heater is satisfied, the Visi
64 LP-171 Rev. 4.10.14 18 1 Step Modulation – Regulates
65 LP-171 Rev. 4.10.14 PART 14 – TROUBLESHOOTING A. ERROR
66 LP-171 Rev. 4.10.14 Table 14 926 Control Board FAULT C
67 LP-171 Rev. 4.10.14 F09 No flame detected – The heater
68 LP-171 Rev. 4.10.14 heater. Installer must also inform
69 LP-171 Rev. 4.10.14 2. Using a spray bottle filled with
7 LP-171 Rev. 4.10.14 DO NOT USE THIS HEATER IF ANY PART
70 LP-171 Rev. 4.10.14 o Visually inspect the primary pre
71 LP-171 Rev. 4.10.14 Figure 33
72 LP-171 Rev. 4.10.14 Figure 34
73 LP-171 Rev. 4.10.14 Figure 35
74 LP-171 Rev. 4.10.14 HEATER START-UP REPORT LIGHT OFF AC
75 LP-171 Rev. 4.10.14 INSPECTION ACTIVITIES DATE LAST CO
76 LP-171 Rev. 4.10.14
77 LP-171 Rev. 4.10.14
78 LP-171 Rev. 4.10.14 MAINTENANCE NOTES
79 LP-171 Rev. 4.10.14 HTP CUSTOMER INSTALLATION RECORD
8 LP-171 Rev. 4.10.14 Water pH between 6.0 and 8.0 o M
9 LP-171 Rev. 4.10.14 Modulating Combustion System Modula
Commentaires sur ces manuels